Cleaning and disinfection - All suppliers - Cleaning and disinfection - Meat and delicatessen industry - Food industry -
Search   


See all sector categories "Food industry"

View associated products
Meat and delicatessen industry
Cutters/choppers/slicers
Other equipment for the delicatessen industry
Food industry furniture
Cleaning and disinfection
Meat mincing machines
Food saws
Wall supports
Other industries
Wine, alcohol and beer
Dairy and cheese industry
Equipment for fruit and vegetables
Drinks (non-alcoholic)
Bread - pastries - biscuits
Isoloirs de vote (translation in progress)
Mesure, transport et conditionnement (translation in progress)
Associated software


Cleaning and disinfection :

2 products Flux RSS
BIO-KATZ BLOCK

BIO-KATZ BLOCK

A Cake manufacturer- in the south east of England, produces a large assortment of cakes which supply all of the major retailers in the UK. The plant operates on a continuous 24 hour basis. For our initial inspection at this site the waste water COD reading was far in excess of 25,000 ppm and Suspended solids in excess of 2,500 ppm. Treatment begun in the waste water by adding 2 Bio-katz blocks. The Bio-katz blocks were installed into the effluent flow where there was a minimal retention period. Over a period of 6 months a stabilization effect was observed. The COD value dropped dramatically to around 5000 ppm and remained around this level whilst the Suspended Solids (SS) reduced to a value of 1600 ppm (mg/L) and remained reasonably constant. Over the next 12 months the values have remained consistent to the values quoted above. In July 2003 a 6 cubic metre fixed film/trickle bed Bioreactor similar to our Clearwater KX4 Bio-plant was designed and installed as means of reducing the COD and SS even further. The plant is now in operation and further reductions in the region of 14-21% further are being measured both in COD and Suspended Solids. >>>
View the product on biokatz.co.uk clearwater services ltd
PUMPING WELLS

PUMPING WELLS

Sewer System Maintenance: The Lift station collecting the wastewater of around 4000 inhabitants is one of the first areas to build up Fat/Grease deposits. The average daily flow rate is 1.5-2000 cubic metres which peaks in the morning from 6-8am and in the evening 7-9pm. This wastewater is loaded with oil & Grease that generates significant deposits on the walls of the lift station as well as the foul odours that disturb the neighborhood. As a result, a municipal technician must go to the station, remove the grease deposits from the walls and pump them out of the system once per week. Results Of Bio-Katz Treatment: At the beginning of the treatment, the lift station was thoroughly cleaned. During the course of the treatment the thickness of the grease layer was monitored. Over the next 4 weeks it was clearly apparent that the grease build up was slowing down as seen by the 2 photographs attached. Also no release of foul odours was measured or detected during this period. Currently the technical staff only clean out the lift station every 5 weeks and then install new Bio-Katz's Blocks. >>>
View the product on biokatz.co.uk clearwater services ltd


  Search    
 
 
 
Search
See all of the sector's products : Food industry